Recomendados
Mais conteúdo relacionado
Mais procurados
Mais procurados (20)
Semelhante a Section Cutting
Semelhante a Section Cutting (20)
Mais de Tamil Mahizhenthi
Mais de Tamil Mahizhenthi (15)
Último
Último (20)
Section Cutting
- 1. Section Cutting Dr Tamil Nila
- 2. Microtomy • It is the means by which tissue is cut into thin sections & attached to a surface of a slide • Performed on Tissue blocks embedded in paraffin wax & frozen sections • Instrument : Microtome
- 3. Microtomes • Mechanical device designed for accurate cutting of thin, uniform tissue sections for microscopic examination • An advancing mechanism moves the block towards the cutting tool for a predetermined distance • The tissue moves vertically towards the cutting tool • Thickness is graduated in microns • A ribbon of sections is produced • Ideal thickness : 4 – 6 microns
- 4. Parts of a microtome • Knife holder with base • Anchors the knife holder to the stage • Knife holder • Blade clamp • Knife tilt • Face plate • Coarse handwheel – for vertical motion (up and down) • Micron adjustment • Safety lock • Advancement hand wheel – forward and backward movement
- 5. Types of Microtome • Rocking microtome • Rotary microtome • Sledge microtome • Sliding Microtome • Freezing microtome
- 6. Rocking Microtome • Oldest • Knife is fixed • Block moves through an arc • Advantages • Cheap, reliable, low maintenance • Very small blocks can be cut • Disadvantages • Size of block that can be cut is limited • Sections are cut in a curved plane • It is to be fitted to avoid movement while cutting
- 7. Rotary Microtome • Basic Mechanism : rotation of the hand wheel by 360 degrees • Most commonly used • Knife is fixed and the tissue moves vertically • Mechanism to advance the block • Retracting • Non retracting • Types • Manual • Semi Automated • Fully automated
- 8. Rotary Microtomes • Advantages • Cuts thin sections 2 -3 microns • Large number of sections • Cuts all type of tissues • Heavier & stable • Large blocks can be cut • Cutting angle can be adjusted • Perfectly flat sections • Disadvantages • Repetitive motion disorder in histotechnicians • Greater chance to cut finger
- 9. Sledge Microtome • Specimen is held stationary • Knife slides across the top of the specimen • Advantages • Very large & hard blocks of tissue • Very stable & not subject to vibration • 24 cm length knife requires less honing • Angle of tilt can be changed • Freezing stage is available • Disadvantages • Slower • Thin sections are difficult to produce
- 10. Sliding Microtome • Knife moves horizontally against a fixed tissue block • Advantage • Cuts both celloidin embedded & paraffin embedded sections • Best results for cutting frozen sections • Advantages • Diagnosis in minutes • Enzyme studies can be done Freezing Microtome
- 11. Microtome knives • Types • Heiffor knife • Larger knives • Classification • Metal knives • Steel • Razor blades • Non metallic knives • Glass • Diamond
- 12. Standard Steel knives • Plano concave • Used in sledge & rotary microtomes • Very concave is used for Celloidin work • Plane –Wedge • Most common • Easy to sharpen • Biconcave • Used in rocking & sledge microtome • Less rigid & prone to vibration • Wedge • Originally designed for cutting frozen sections • Tool Edge • for very hard tissues • Tungsten carbide at edge
- 13. Parts of metal knives • Heel of the knife • Angle between cutting edge & end of the knife nearest to handle • Toe of the knife • Angle between cutting edge & end of the knife farthest from handle • Honing guide/ knife back sheath • Gives angle while honing & stropping • Handle
- 14. Microtome knife angles • Wedge angle • Angle between the sides of the knife • Facet angle • Angle between the actual cutting edges • Greater than the wedge angle • Clearance angle or tilt angle • Angle between the block face and lower cutting facet of knife • Only knife angle that can be adjusted • Cutting angle • Angle between the block face & upper cutting facet of the knife • Rake angle • 90 degree – angle of upper cutting facet of knife • Larger rake angle easier cutting
- 16. Trimming the block • At least 2mm of wax is left surrounding the tissue on all 4 sides • Exposes the embedded tissue • Edges of the block should be parallel
- 17. Fixing the block on the microtome • Heat a flat spatula ( 1 – 2 inches) in a Bunsen flame • Melt the wax by placing block on spatula • Press the block on the holder & wait for it to harden
- 18. Technique • Place the microtome on a sturdy table • Insert knife & screw tight • Mount the block within the clamp of the holder • Adjust tilt of the knife = 2 – 6 degree • Adjust the block holder – wax block almost touching the level of the knife • Tighten all the adjusting screws
- 19. Technique • Bevel of the knife face is parallel to the cutting motion • Section thickness = 10 – 15 microns • Operate until complete sections are cut • Reset section thickness to 4 – 5 microns • Ice can be applied to the surface of block -> wiped -> cut • Right hand operates the microtome • Left hand holds sections away from the knife • Gentle breathing on the block removes creases
- 20. Technique • Ribbon formation • Heat formation between the block & knife • Sections adhere to each other • Sections are held with • Blunt forceps • Camel hair brush • Fingers • Sections are floated on a warm water bath • Collected with slides
- 21. Fixing the sections to slides • Water bath method • 25 – 30 cm in dm • 8 – 10 cm in depth • Black colored water baths • To see the creases in the sections easily • Thermostatically controlled • Temperature is 5 – 10 degree Celsius below the melting point of paraffin wax
- 22. Water bath method • Sections lifted from the microtome & transferred to the surface of water • One end followed by other end of the tissue section is gently lowered onto the water bath • Use dissecting needles to iron out the creases • Albuminised slide is dipped obliquely • While withdrawing one end of the ribbon is attached to the slide • Reposition the section on the slide if necessary • Slide is marked immediately
- 23. Water bath method • Slides in upright position to drain excess water • Mounted slides are placed in an incubator at 37 degree celcius for 1 hr • For albuminised slides • Place in 60 degree inside oven x 2 hrs • To dry & coagulate the albumin • Disadvantages • Bacterial contamination • Floaters
- 24. Adhesives • Mayer’s glycerol albumin • 1 volume or glycerol • 1 volume of egg white • Pinch of thymol • Starch paste • Chrome gelatin • Poly – L – lysine • 3 – Aminopropyltriethoxysilane • Araldite • Charged or plus slides
- 26. Hot stage/ Plate method • Metal top heated to 45 – 50 degrees • Slide placed on the stage • Flooded with distilled water • Sections are floated • When sections are completely flat, remove the plate • Drain excess water
- 27. Warmed slide method • Same as hot stage • After the creases are removed • Slide is held over a Bunsen burner for a seond • Place in oven for drying
- 28. Why creases appear? • Block wasn’t cold when cut • Compression of wax by a blunt knife • Poor bevel on the knife • Incorrectly tilted knife
- 29. Why sections disappear? • Exposure to strong alkaline solution during staining • Tissue containing blood & mucous • Decalcified tissues • CNS tissues • Sections exposed to extreme temperatures
- 30. Problems faced Problems Reason Remedy Scored sections Knife edge is damaged with small nicks Hard particles in the tissue or paraffin Use different part of the blade or replace it Decalcify if needed Remove the hard particle with scalpel Curled sections Dirty Knife Blunt knife Too much Tilt in the knife Clean Sharpen Reduce the tilt Thick & thin zones in the same section Blade / block is loose in holders Too much tilt Hard tissue / Paraffin Dull blade Tighten by adjusting screws Reduce the tilt angle Use Softening agent Replace the blade / remove excess paraffin
- 31. Problems faced Problem Reason Remedy Crumbling of sections on cutting Blunt knife Soft wax Crystallised wax Sharpen or replace Apply ice to cool the cutting surface Rapidly cool the wax Curving of ribbon/ consecutive sections Block edges are not parallel to each other & to the knife edge Dull blade Excessive paraffin Tissue varying in consistency Trim block edges until parallel to each other Correct block edge parallel to knife Sharpen/ Replace the blade Trim the excess Re – orient the block Thick & Thin Sections Paraffin too soft for tissue Insufficient clearance angle Faulty microtome mechanisms Blade or block loose in holders Cool block with ice / re-embed in wax with higher melting point Increase clearance angle Lubricate microtome Tighten holders
- 32. Problems faced Problems reasons Remedies Sections not forming ribbons Paraffin too hard for sectioning Debris on knife Incorrect clearance angle Re-embed in lower melting point paraffin Clean with xylene Keep optimal clearance angle Sections attach to block on return stroke Insufficient clearance angle Edge of the blade/Block with debris Static electricity on the ribbon Increase clearance angle Clean knife with xylene Trim edges of the block Place static guards or dryer sheets Incomplete section Improper impregnation of tissue with paraffin Incorrect embedding Superficially cut sections Reprocess the block Re embed the tissue Reface the block or cut deeper
- 33. Problems faced Problems Reason Remedy Excessive compression Dull blade Soft paraffin Sharpen/ Replace Cold block face Sections expand or disintegrate on water bath Improper impregnation of tissue High temperature of water Re process Reduce the temperature Sections roll into coil Dull blade Rake angle too small Thick sections Sharpen or replace Reduce blade tilt Reduce thickness of section
- 34. Microtomy requirements for good histological sections • High quality sharp blades • Optimize knife tilt angle for each microtome & blade type • Trim blocks carefully • Avoid freezing damage to tissue block • Use cold blocks • Cut sections slowly/ gently with a uniform, slow rotation
- 35. References • Bancroft’s theory and Practice of histological techniques • Histopathology techniques & its management by Ramadas Nayak • Basic & Advanced laboratory techniques in Histopathology & cytology by Pranab Dey